Disassembly Guide for Asus N80/N81 series

webmaster Tutorial 1 Comment

In this guide, I’ll show you how to disassemble Asus N80/N81 series.

Read the whole procedure thoroughly before you start.

 

Remove the battery.
 

And all the screws on the bottom cover.
 

When we open the CPU cover, we can see the graphics card, memory and so on.

Remove 4 screws securing the graphics card.
 

Then pull it up, the graphics card is disassembled.
 

Now we need to disassemble the radiator module.

Remove these screws marked below.

 

And then pull from the left, it is unloaded.
 

Now we can unload CPU. Unscrew it counterclockwise with a straight screwdriver.
 

Release the memory chips as the direction shows.
 

Now we can open the hard drive cover and remove the screws, take out the hard drive.
 

 

 



Remove 2 screws and take out the TV card.
 

Remove them in order.
 

Then MINIPCI-E riser card.
     


Wi-Fi network card.
 

Remove the screws, and push out the optical drive.
 

Turn it over. Let’s remove the keyboard.

Insert a tweezer into the four parts marked below to loosen the clips.

Then pull it up, we can remove the keyboard.
 

Then remove the ribbon wire.
 

Open the screen cable cover, unplug the cable.
     

Unscrew 2 screws securing the revolving axis.
    

Afterwards, we need to remove these screws securing C cover.

Pull it up and unload it.
 

Unplug the Bluetooth cable, the microphone cable and the audio cable
 

 

 

When we remove the motherboard, there are 2 screws securing it on the left.

Unscrew them.
 

Finally we can take the whole motherboard out.



One thought on “Disassembly Guide for Asus N80/N81 series

  1. Thank you VERY much for the N81Vp disassembly guide!!! I’ve been looking for this for a long time.

    I need to replace the RTC battery on my N81Vp and from your photos I think I now see where the battery (CR2032?) is located.

    Is there any way to replace the RTC battery without completely removing the main board? I’ve been having problems with the main board “THRM” temp sensor and also have a weak or dead RTC battery. I wanted to make sure a new battery did not solve the “No Data” temp sensor problem before replacing the whole motherboard or junking the N81Vp. The temp sensor will occasionally go to “FATAL” and put the notebook into hibernation. Removing main battery & discharging CMOS seems to always reset the sensor to “No Data”, with fan running continuously at high speed.

    Thank you for any advice you can give me but if not, thanks again for this disassembly guide!!!

Leave a Reply

Your email address will not be published. Required fields are marked *